Another generator problem? Two questions?

[Larry]

Tom,
I hope you did not let the smoke out!!!

Sea Ya
Larry
NYC
84 35FCSB

----- Original Message ----
From: thomas_sorrentino
To: WanderlodgeForum@yahoogroups.com
Sent: Monday, May 28, 2007 4:05:03 PM
Subject: [WanderlodgeForum] Re: Another generator problem? Two questions?













Ralph,



ok I'm done painting now! My wife thought painting was more important

than fixing the generator LOL!



not pushing start switch pushing start switch

P=12 vdc

1=0 vdc 1=0 vdc

2=0 vdc 2=0 vdc

3=12 vdc 3=0 vdc

5=0 vdc 5=0 vdc



All wires and connections look good. There is a faint smell of burnt

electrical, when I took off control box cover.



Tom Sorrentino

1987 PT38

Bedford Hills, NY



--- In WanderlodgeForum@ yahoogroups. com, "Ralph L. Fullenwider"

wrote:

>

> Morning Tom:

>

> Did you remove the wire from the post and check it as well? OK I

know this

> is redundant but double check the fuse holder to be sure a wire is

not

> burned off inside the control box. Next remove the top off the

control box

> and locate the terminal strip in the bottom of the box. Now make a

drawing

> of the terminal strip so you can make check marks as you do

electrical

> measurements. The terminal strip from left to right is

> P,1,2,3,4,5, 6,7,8,9,20, 34,35,55

>

> Set your meter, with the fuse in place, to dc volts, and put the

black lead

> of your meter with an jumper clip lead to ground. The do your

measurements

> with the red lead. You should have 12vdc on the terminal strip

marked P. If

> no 12 vdc then the fuse, fuse holder or wire is bad or connection

corroded.

> If you have power there, then with the red lead on terminals 1,2,3

you

> should not read voltage until you switch the start switch. With the

start

> switch held in the start position you should have 12 vdc on 1,2,and

3.

> Terminal 4 is the common or ground, Terminal 5, we are going to

check if C

> relay is pulling in. With the red lead on Terminal 5, switch the

start and

> if you have power then C relay is pulling in. This also checks the

normally

> closed contacts of the CR (110vac) relay. Terminal 6 is the pre

heat

> switch. Terminal 7 there is no connection. We will stop there for

now,

> because you should have proved there is power somewhere in the

above. If

> not then we will do a diode check on 4 diodes. The diodes, in this

case,

> will be square body units about 1/4 inch or so square with two tabs

on each

> end.

>

> So do those checks above first then we can go on after we find out

where it

> is or is not.

>

> Safe travels,

>

> Ralph and Charolette Fullenwider

> 84FC35

> Ralph's RV Solutions, Duncan, Oklahoma

>

> At 03:22 PM 5/28/2007 +0000, you wrote:

> >Ralph,

> >

> >I checked the voltage on the small terminal on the starter

solenoid.

> >0 vdc, when I hit the start switch. Next step please?

> >

> >Tom Sorrentino

> >1987 PT38

> >Bedford Hills, NY

> >

> >

>














<!--

#ygrp-mlmsg {font-size:13px;font-family:arial, helvetica, clean, sans-serif;}
#ygrp-mlmsg table {font-size:inherit;font:100%;}
#ygrp-mlmsg select, input, textarea {font:99% arial, helvetica, clean,
sans-serif;}
#ygrp-mlmsg pre, code {font:115% monospace;}
#ygrp-mlmsg * {line-height:1.22em;}
#ygrp-text{
font-family:Georgia;
}
#ygrp-text p{
margin:0 0 1em 0;}
#ygrp-tpmsgs{
font-family:Arial;
clear:both;}
#ygrp-vitnav{
padding-top:10px;font-family:Verdana;font-size:77%;margin:0;}
#ygrp-vitnav a{
padding:0 1px;}
#ygrp-actbar{
clear:both;margin:25px 0;white-space:nowrap;color:#666;text-align:right;}
#ygrp-actbar .left{
float:left;white-space:nowrap;}
.bld{font-weight:bold;}
#ygrp-grft{
font-family:Verdana;font-size:77%;padding:15px 0;}
#ygrp-ft{
font-family:verdana;font-size:77%;border-top:1px solid #666;
padding:5px 0;
}
#ygrp-mlmsg #logo{
padding-bottom:10px;}

#ygrp-vital{
background-color:#e0ecee;margin-bottom:20px;padding:2px 0 8px 8px;}
#ygrp-vital #vithd{
font-size:77%;font-family:Verdana;font-weight:bold;color:#333;text-transform:upp\
ercase;}
#ygrp-vital ul{
padding:0;margin:2px 0;}
#ygrp-vital ul li{
list-style-type:none;clear:both;border:1px solid #e0ecee;
}
#ygrp-vital ul li .ct{
font-weight:bold;color:#ff7900;float:right;width:2em;text-align:right;padding-ri\
ght:.5em;}
#ygrp-vital ul li .cat{
font-weight:bold;}
#ygrp-vital a {
text-decoration:none;}

#ygrp-vital a:hover{
text-decoration:underline;}

#ygrp-sponsor #hd{
color:#999;font-size:77%;}
#ygrp-sponsor #ov{
padding:6px 13px;background-color:#e0ecee;margin-bottom:20px;}
#ygrp-sponsor #ov ul{
padding:0 0 0 8px;margin:0;}
#ygrp-sponsor #ov li{
list-style-type:square;padding:6px 0;font-size:77%;}
#ygrp-sponsor #ov li a{
text-decoration:none;font-size:130%;}
#ygrp-sponsor #nc {
background-color:#eee;margin-bottom:20px;padding:0 8px;}
#ygrp-sponsor .ad{
padding:8px 0;}
#ygrp-sponsor .ad #hd1{
font-family:Arial;font-weight:bold;color:#628c2a;font-size:100%;line-height:122%\
;}
#ygrp-sponsor .ad a{
text-decoration:none;}
#ygrp-sponsor .ad a:hover{
text-decoration:underline;}
#ygrp-sponsor .ad p{
margin:0;}
o {font-size:0;}
.MsoNormal {
margin:0 0 0 0;}
#ygrp-text tt{
font-size:120%;}
blockquote{margin:0 0 0 4px;}
.replbq {margin:4;}
-->









________________________________________________________________________________​\
____Building a website is a piece of cake. Yahoo! Small Business gives you all
the tools to get online.
http://smallbusiness.yahoo.com/webhosting

[Non-text portions of this message have been removed]