6" SS EXHAUST STACK
|
12-04-2008, 16:40
Post: #70
|
|||
|
|||
6" SS EXHAUST STACK
Wallace,
Just stick it in the end of the tube. You could go to the hardware store and get some 6" CPVC with a cap and do the same thing. if you go the baggie route. Use rubber bands or little bungies, if you use masking tape the sun will bake it onto the pipe and you'll need some kind of solvent to get it off. That mean getting up on top of the coach. Kurt Horvath 95 PT42 10AC --- In WanderlodgeForum@yahoogroups.com, Wallace Craig > > My stack turns 90* to the starboard; don't see how "stack hat" would work. Baggie and scotch tape is sure cheaper. > > > Wallace Craig > 95 WLWB 42 > Azle, Texas > > --- On Thu, 12/4/08, Kurt Horvath > > From: Kurt Horvath > Subject: [WanderlodgeForum] Re: 6" SS EXHAUST STACK > To: WanderlodgeForum@yahoogroups.com > Date: Thursday, December 4, 2008, 9:16 PM > > Wallace, > > Here is a safe, clean, easy fix, for long term parking, to protect > against rain entering the exhaust. You do not need to climb on top of > your coach, just use the included pole and storage bag when you don't > need it. > > Make sure you copy and past all of the address below. > > http://www.iowa80.com/DirectionsWEB/webc...splay.php? > itemid=98467 > > Kurt Horvath > 95 PT 42 > 10AC > > > > > > > --- In WanderlodgeForum@yahoogroups.com, Pete Masterson > wrote: > > > > I haven't researched it, but the problem of the 6" stack is the > issue > > -- almost all accessories max out at 5" diameter. Someone > somewhere > > might offer a 6" flap stack cover. > > > > In the interim, perhaps a (metal) bucket and bungee cord would > > provide protection. Use a small, light (kids) bucket, and no > bungee > > cord and it will remove itself when you start up -- otherwise, be > > sure not to forget to remove it! > > > > Pete Masterson > > '95 Blue Bird Wanderlodge WBDA 42 > > aeonix1@ > > On the road at Williams, AZ > > > > > > > > On Dec 4, 2008, at 9:51 AM, Wallace Craig wrote: > > > > > For us pore lawyer types; simple is the best solution. Do you > know > > > if the flap like I described is available that fits the coach > that > > > you and I have with 90 degree exhaust end?? I am going to be on > > > South Padre Island for Jan & Feb and would like to keep water > out. > > > > > > Wallace Craig > > > 95 WLWB 42 > > > Azle, Texas > > > > > > > > > --- On Thu, 12/4/08, Kurt Horvath > > > From: Kurt Horvath > > > Subject: [WanderlodgeForum] Re: 6" SS EXHAUST STACK > > > To: WanderlodgeForum@yahoogroups.com > > > Date: Thursday, December 4, 2008, 10:20 AM > > > > > > Hi Wallace, I looked into several options, the one I liked most > was > > > bi-metalic valves. That's a strip of metal that expands and > > > contracts when heated and cooled. It's used in some muffler > > > applications. When it's cold it leaves a gap over a hole when > > > heated it contracts and covers the opening. Easy few parts > > > automatic operation, simular to what you described. The current > > > prototype can be modified in this manner. The electric valve can > be > > > removed and a flange can be put in it's place with any type of > > > device from a bung with a plug to the exhaust dump valve to > drain > > > away the water. I wanted the trap to be capable of draining away > an > > > possible water flow that might be encountered. Five gallons a > min. > > > is most likly more than enough, unless that little son of gun > > > Murphy shows up. L.O.L. Of course the rain cap will do the job > but > > > it's not a very attractive option, The 90 degree turn out pipe > also > > > works well but I've been trying to delete as many turns in the > > > pipes as possible. The system that will be offered to the > general > > > public is a direct replacement of OEM parts for your coach, The > > > photos that will be posted soon are of the exhaust going into my > > > coach. Kurt Horvath 95 PT 42 10AC --- In > > > WanderlodgeForum@yahoogroups.com, Wallace Craig > > > > wrote: > > Kurt, I am probably the last person on earth that > you > > > should tale advise from about anything mechanical. Having said > > > that; can you not install a flap at the end of the exhaust that > is > > > weighted to stay closed when the engine is not operating? I know > I > > > have seen it on truck applications. > Keep Tennessee clean & > green, > > > maybe I will get back that way sometime soon. Fuel is $2.44 at > > > Racetrack in Azle. Happy holidays. > > > Wallace Craig > > 95 > WLWB > > > 42 > Azle, Texas > > --- On Thu, 12/4/08, Kurt Horvath > > > > wrote: > > From: Kurt Horvath > > > [WanderlodgeForum] Re: 6" SS EXHAUST STACK > To: > > > WanderlodgeForum@yahoogroups.com > Date: Thursday, December 4, > > > 2008, 8:58 AM > > Here we are 6 weeks after our last posts on > my > > > exhaust build. I > should have some photos today rain > permitting. > > > > > Some forum members brought up several points that I had not > > > > fully > considered or researched. > > Some of the mods are a > 90 > > > degree turnout pipe up top, a 30 degree > miter cut with a rain > > > visor and a drain tube on the necks bottom > inside curve of the > > > turn out. This should keep most of the rain out. > > Not being > able > > > to decide on exactly which type of exit I wanted I > have built, > > > two types the 90 I just described and a straight stack > with a > > > rain cap. > > Yes David the same as on your JD, At least I > polished > > > it up. > > If you look at your PT's exhaust it's a > straight shot > > > from the > exhaust opening straight into your motor. Systems > with > > > mufflers have > water traps and some have drains as well, small > > > holes drilled into > the bottom of the muffler. I opted out of a > > > muffler, for a straight > stack, so some sort of rain trap had > to > > > be created that would not > interfere with the exhaust gas flow > and > > > trap and drain rain > accumulation of any proportions. A 5" > hole > > > can accumulate a lot of > water in a daily south Florida > afternoon > > > rain, day after day sooner > or later your going to fill the > block > > > with water. According to > Detroit this is a problem. DUH!!! > > > Detroit used the words Catastrophic > Failure several times. > > > > > > This first post has a photo of the test drain trap. Look on the > > > Home > Page for photo in Bumpersbird Album last pic. What you > are > > > looking at > is the drain section with the garden hose on full > > > flow. 5 gallons per > min. As you can see it gets most of the > flow. > > > The section of tube on > the ground has been cut down to 6" > long > > > with a 3.5" electric exhaust > dump valve installed on a > flange > to > > > open and close the water trap. At > this point it is manually > > > operated by a rocker switch or a by a > remote key fob. > > > I'm > > > working on a thermal activated switch that will close the valve > > > > > upon heating or a sensor that will open the valve if it detects > > > water > in the trap. The surest method of operation is to open > it > > > when parked > and close it before you crank up the motor > > > > Some > > > of my modification will most likely raise some eyebrows, and the > > > > > commentary which when taken in the proper context may led to > > > another > modification. > > Most likely NOT a this stage, > unless > of > > > course someone spots a > glaring defect or error in my build. > > > > > > > I'm ready to install the new pipes and go somewhere in the coach, > > > > > > she's been in the barn since Aug. On the up side I have gotten > > > > > several large fix's and rebuilds done on her since I knew she > would > > > > sitting for a while. > > Comments, criticism, suggestions, > > jokes, > > > remarks, welcomed. > > Currently this is a prototype for my > coach, > > > a direct replacement for > the 95-96 PT42's is in the works. > It > > > will be built Stainless Steel > and will be a direct bolt in > > > application, to replace the OEM parts. > > > > Kurt > Horvath > 95 > PT > > > 42 > 10AC > > > ------------------------------------ > > > Yahoo! > > > Groups Links > ------------------------------------ Yahoo! > Groups > > > http://groups.yahoo.com/group/WanderlodgeForum/join (Yahoo! ID > > > > > > > > > ------------------------------------ > > Yahoo! Groups Links > |
|||
« Next Oldest | Next Newest »
|
Messages In This Thread |
6" SS EXHAUST STACK - erniecarpet@... - 10-21-2008, 07:11
6" SS EXHAUST STACK - Kurt Horvath - 10-21-2008, 10:52
6" SS EXHAUST STACK - Rob Robinson - 10-21-2008, 11:02
6" SS EXHAUST STACK - Leroy Eckert - 10-21-2008, 11:05
6" SS EXHAUST STACK - Leroy Eckert - 10-21-2008, 11:24
6" SS EXHAUST STACK - David Brady - 10-21-2008, 16:28
6" SS EXHAUST STACK - erniecarpet@... - 10-30-2008, 04:37
6" SS EXHAUST STACK - erniecarpet@... - 10-30-2008, 06:05
6" SS EXHAUST STACK - Kurt Horvath - 10-30-2008, 08:30
6" SS EXHAUST STACK - erniecarpet@... - 10-30-2008, 08:53
6" SS EXHAUST STACK - Kurt Horvath - 10-30-2008, 09:56
6" SS EXHAUST STACK - mbulriss - 10-30-2008, 10:38
6" SS EXHAUST STACK - Kurt Horvath - 10-30-2008, 11:39
6" SS EXHAUST STACK - Gregory OConnor - 10-30-2008, 12:48
6" SS EXHAUST STACK - David Brady - 10-30-2008, 14:02
6" SS EXHAUST STACK - Kurt Horvath - 10-30-2008, 15:56
6" SS EXHAUST STACK - Kurt Horvath - 10-30-2008, 16:33
6" SS EXHAUST STACK - Kurt Horvath - 10-30-2008, 17:06
6" SS EXHAUST STACK - David Brady - 10-30-2008, 17:31
6" SS EXHAUST STACK - David Brady - 10-31-2008, 08:39
6" SS EXHAUST STACK - Kurt Horvath - 10-31-2008, 09:14
6" SS EXHAUST STACK - ronmarabito2002 - 10-31-2008, 12:42
6" SS EXHAUST STACK - David Brady - 10-31-2008, 14:05
6" SS EXHAUST STACK - David Brady - 10-31-2008, 14:30
6" SS EXHAUST STACK - Kurt Horvath - 10-31-2008, 17:24
6" SS EXHAUST STACK - Pete Masterson - 11-01-2008, 04:18
6" SS EXHAUST STACK - David Brady - 11-01-2008, 05:33
6" SS EXHAUST STACK - Kurt Horvath - 11-01-2008, 06:25
6" SS EXHAUST STACK - Kurt Horvath - 11-01-2008, 06:47
6" SS EXHAUST STACK - David Brady - 11-01-2008, 06:50
6" SS EXHAUST STACK - Rob Robinson - 11-01-2008, 06:53
6" SS EXHAUST STACK - David Brady - 11-01-2008, 07:33
6" SS EXHAUST STACK - Gregory OConnor - 11-01-2008, 08:16
6" SS EXHAUST STACK - Kurt Horvath - 11-01-2008, 08:41
6" SS EXHAUST STACK - Kurt Horvath - 11-01-2008, 08:55
6" SS EXHAUST STACK - ronmarabito2002 - 11-01-2008, 11:59
6" SS EXHAUST STACK - Gregory OConnor - 11-01-2008, 12:13
6" SS EXHAUST STACK - David Brady - 11-01-2008, 12:14
6" SS EXHAUST STACK - Kurt Horvath - 11-01-2008, 12:30
6" SS EXHAUST STACK - David Brady - 11-01-2008, 13:27
6" SS EXHAUST STACK - David Brady - 11-01-2008, 14:30
6" SS EXHAUST STACK - David Brady - 11-01-2008, 16:35
6" SS EXHAUST STACK - Kurt Horvath - 11-01-2008, 16:41
6" SS EXHAUST STACK - David Brady - 11-01-2008, 18:37
6" SS EXHAUST STACK - Kurt Horvath - 11-01-2008, 18:41
6" SS EXHAUST STACK - David Brady - 11-01-2008, 18:49
6" SS EXHAUST STACK - David Brady - 11-02-2008, 02:09
6" SS EXHAUST STACK - Kurt Horvath - 11-02-2008, 03:17
6" SS EXHAUST STACK - hippieforever3 - 11-02-2008, 06:41
6" SS EXHAUST STACK - rogerwwebb@... - 11-03-2008, 03:25
6" SS EXHAUST STACK - Joyce and Richard Hayden - 11-03-2008, 08:12
6" SS EXHAUST STACK - Rob Robinson - 11-03-2008, 08:25
6" SS EXHAUST STACK - Gregory OConnor - 11-03-2008, 12:14
6" SS EXHAUST STACK - Joyce and Richard Hayden - 11-03-2008, 15:41
6" SS EXHAUST STACK - Tom McCarthy - 11-05-2008, 18:14
6" SS EXHAUST STACK - Pete Masterson - 11-06-2008, 03:18
6" SS EXHAUST STACK - Kurt Horvath - 12-04-2008, 02:58
6" SS EXHAUST STACK - Wallace Craig - 12-04-2008, 03:08
6" SS EXHAUST STACK - Kurt Horvath - 12-04-2008, 04:20
6" SS EXHAUST STACK - David Brady - 12-04-2008, 04:40
6" SS EXHAUST STACK - Wallace Craig - 12-04-2008, 04:51
6" SS EXHAUST STACK - robert nloomas - 12-04-2008, 07:16
6" SS EXHAUST STACK - Wallace Craig - 12-04-2008, 07:49
6" SS EXHAUST STACK - Pete Masterson - 12-04-2008, 12:14
6" SS EXHAUST STACK - Pete Masterson - 12-04-2008, 12:18
6" SS EXHAUST STACK - Kurt Horvath - 12-04-2008, 15:16
6" SS EXHAUST STACK - Wallace Craig - 12-04-2008, 15:24
6" SS EXHAUST STACK - David Brady - 12-04-2008, 15:47
6" SS EXHAUST STACK - Kurt Horvath - 12-04-2008, 16:28
6" SS EXHAUST STACK - Kurt Horvath - 12-04-2008 16:40
6" SS EXHAUST STACK - Terry Neal - 12-04-2008, 16:56
6" SS EXHAUST STACK - Stephen Birtles - 12-05-2008, 01:23
6" SS EXHAUST STACK - Chris Fogleman - 12-05-2008, 03:33
6" SS EXHAUST STACK - Terry Neal - 12-05-2008, 04:29
|
User(s) browsing this thread: 2 Guest(s)